Datenblatt-pdf.com


HLG-60H-C350 Schematic ( PDF Datasheet ) - Mean Well

Teilenummer HLG-60H-C350
Beschreibung 70W Single Output LED Power Supply
Hersteller Mean Well
Logo Mean Well Logo 




Gesamt 13 Seiten
HLG-60H-C350 Datasheet, Funktion
70W Single Output LED Power Supply
HLG-60H-C series
¡½ Features :
¡E Constant current design
¡E Universal AC input / Full range (up to 305VAC)
¡E Built-in active PFC function
¡E High efficiency up to 91%
¡E Protections: Short circuit / Over voltage / Over temperature
¡E Cooling by free air convection
¡E Output current adjustable through output cable or internal potentiometer
¡E IP67 / IP65 design for indoor or outdoor installations
¡E Three in one dimming function (1~10Vdc or 10V PWM signal or resistance)
¡E Suitable for dry / damp / wet locations
¡E 5 years warranty (Note.5)
(HLG-60H-C700 only)
F 110 M M SELV
IP65 IP67
(HLG-60H-C700 only)
HLG-60H-C350 A A : IP65 rated. Constant current level can be adjusted through internal potentiometer.
B : IP67 rated. Constant current level adjustable through output cable with 1~10Vdc or 10V PWM signal or resistance.
D (option) : IP67 rated. Timer dimming function, contact MEAN WELL for details.
SPECIFICATION
MODEL
HLG-60H-C350
HLG-60H-C700
OUTPUT
RATED CURRENT
CURRENT ACCURACY
350mA
¡Ó 5.0%
700mA
CONSTANT CURRENT REGION Note.6 100 ~ 200V
50 ~ 100V
RATED POWER
RIPPLE CURRENT
70W
¡Ó 5%
70W
RIPPLE & NOISE
Note.7 1Vp-p
0.5Vp-p
CURRENT ADJ. RANGE
LINE REGULATION
Can be adjusted by internal potentiometer A type only
210 ~ 350mA
¡Ó 1%
420 ~ 700mA
¡Ó 1%
SETUP, RISE TIME
1500ms, 80ms / 115VAC at full load 1000ms, 80ms / 230VAC at full load
HOLD UP TIME (Typ.)
16ms at full load 230VAC / 115VAC
INPUT
VOLTAGE RANGE Note.2 90 ~ 305VAC 127VDC ~ 431VDC
FREQUENCY RANGE
47 ~ 63Hz
POWER FACTOR (Typ.)
PF>0.98/115VAC, PF>0.96/230VAC, PF>0.94/277VAC at full load (Please refer to "Power Factor Characteristic" curve)
TOTAL HARMONIC DISTORTION Total harmonic distortion will be lower than 20% when output loading is 75% or higher
EFFICIENCY (Typ.)
91%
90.5%
AC CURRENT (Typ.)
0.69A / 115VAC 0.35A / 230VAC 0.29A / 277VAC
INRUSH CURRENT (Typ.) COLD START 70A / 230VAC
LEAKAGE CURRENT
<0.75mA / 277VAC
SHORT CIRCUIT
Hiccup mode, recovers automatically after fault condition is removed
OVER VOLTAGE
PROTECTION
OVER TEMPERATURE
WORKING TEMP.
230 ~ 250V
120 ~ 140V
Protection type : Shut down o/p voltage with auto-recovery or re-power on to recovery
85¢J¡Ó 10¢J (RTH2)
Protection type : Shut down o/p voltage, re-power on to recover
¢J-40 ~ +70 (Refer to "Derating Curve")
WORKING HUMIDITY
ENVIRONMENT STORAGE TEMP., HUMIDITY
TEMP. COEFFICIENT
10 ~ 95% RH non-condensing
¢J-40 ~ +80 , 10 ~ 95% RH
¡Ó0.03%/¢J (0 ~ 50¢J )
VIBRATION
10 ~ 500Hz, 5G 12min./1cycle, period for 72min. each along X, Y, Z axes
SAFETY STANDARDS Note.3 UL8750, CSA C22.2 No. 250.0-08, EN61347-1, EN61347-2-13 independent, IP65 or IP67 approved
WITHSTAND VOLTAGE
SAFETY &
ISOLATION RESISTANCE
EMC
EMC EMISSION
I/P-O/P:3.75KVAC I/P-FG:2KVAC O/P-FG:0.5KVAC
¢JI/P-O/P, I/P-FG, O/P-FG:100M Ohms / 500VDC / 25 / 70% RH
¡ÙCompliance to EN55015, EN61000-3-2 Class C ( 60% load) ; EN61000-3-3
EMC IMMUNITY
MTBF
Compliance to EN61000-4-2,3,4,5,6,8,11, EN61547, heavy industry level (surge L,N-FG: 4KV), criteria A
¢J338K hrs min. MIL-HDBK-217F (25 )
OTHERS DIMENSION
171*61.5*36.8 mm (L*W*H)
NOTE
PACKING
0.73Kg; 20pcs/15.6Kg/0.9CUFT
¢J1. All parameters NOT specially mentioned are measured at 230VAC input, rated load and 25 of ambient temperature.
2. Derating may be needed under low input voltages. Please check the static characteristics for more details.
3. Safety and EMC design refer to EN60598-1, CNS15233, GB7000.1.
4. The power supply is considered as a component that will be operated in combination with final equipment. Since EMC performance will be affected by the
complete installation, the final equipment manufacturers must re-qualify EMC Directive on the complete installation again.
5. Refer to warranty statement.
6. Constant current operation region is within 50% ~100% rated output voltage. This is the suitable operation region for LED related applications, but please
reconfirm special electrical requirements for some specific system design.
7. Ripple & noise are measured at 20MHz of bandwidth by using a 12" twisted pair-wire terminated with a 0.1uf & 2.2uf parallel capacitor.
File Name:HLG-60H-C-SPEC 2012-11-14
Free Datasheet http://www.Datasheet4U.com






HLG-60H-C350 Datasheet, Funktion
70W Single Output LED Power Supply
HLG-60H-C series
WATERPROOF CONNECTION
¡· Waterproof connector
Waterproof connector can be assembled on the output cable of HLG-60H-C to operate in dry/wet/damp or outdoor environment.
AC
source
I/P
HLG-60H-C
O/P
Size Pin Configuration (Female)
Size Pin Configuration (Female)
M12
Order No.
Suitable Current
¡· Cable Joiner
4-PIN
5A/PIN
M12-04
10A max.
66
26 20
5-PIN
5A/PIN
M12-05
10A max.
M15
Order No.
Suitable Current
2-PIN
12A/PIN
M15-02
12A max.
CJ04-1 suitable for 14AWG~16AWG
CJ04-2 suitable for 18AWG~22AWG
LED Lamp
Up to four wires can be connected through this cable joiner by
soldering or clamping by tools.
HLG-60H-C
O/P Wires
¡° CJ04 cable joiner can be purchased independently for user's own assembly.
MEAN WELL order No. : CJ04-1, CJ04-2.
LED Lamp
File Name:HLG-60H-C-SPEC 2012-11-14
Free Datasheet http://www.Datasheet4U.com

6 Page









HLG-60H-C350 pdf, datenblatt
HLG-60H-C series
RELIABILITY TEST
NO TEST ITEM
1 TEMPERATURE RISE TEST
ENVIRONMENT TEST
SPECIFICATION
TEST CONDITION
MODELHLG-60H-C700
1. ROOM AMBIENT BURN-IN18 HRS
I/P230VAC O/PFULL LOAD Ta= 28.4
2. HIGH AMBIENT BURN-IN0.5 HRS
I/P230VAC O/PFULL LOAD Ta= 53.7
RESULT
2 OVER LOAD BURN-IN TEST
3 LOW TEMPERATURE
TURN ON TEST
4 HIGH HUMIDITY
HIGH TEMPERATURE
HIGH VOLTAGE
TURN ON TEST
5 TEMPERATURE
COEFFICIENT
NO Position
P/N
ROOM AMBIENT HIGH AMBIENT
Ta=28.4
Ta=53.7
1 LF1
TR732-R5
2 LF2
LF855
3 BD1 4A/800V SILICON UD4KB80
4 L1
TR991-R1
5 L3
TF2442
6 C11
474/450V 10% P=10 MEX
7 D3
2A/800V GP20K T-52mm
8 D1
MUR460 4A/600V
9
C5
47u/450V 10Kh -40~105
16*25 CST
10 D2
2A/800V GP20K T-52mm
11 Q3
2SK3799 8A/900V TO220F
12 Q1 TK10A60D 10A/600V TO220F
13 U1
FAN6921MR SOP
14 C18 47u/50V UL10Kh 6.3*11 YXM
15 C16 22u/50V UL10Kh 5*11 YXM
16
RTH2
100K3Φ TTC3A104F4193EY
1%
17 T1
TF2443-R1
18 D100 31DF4 3A/400V DO-201AB
19 C201 47u/50V UL10Kh 6.3*11 YXM
20 C203 22u/50V UL10Kh 5*11 YXM
21 C105
56u/160V 105 10*20 KXJ
22 LF100
TR1020-R1
23 C111
56u/160V 105 10*20 KXJ
48.2
51.0
52.3
52.8
53.4
52.8
54.2
54.6
53.2
61.6
54.0
52.5
57.0
56.7
53.7
52.4
64.0
56.8
56.3
54.1
57.1
52.0
54.0
67.2
69.9
71.4
71.6
72.3
71.8
73.0
73.6
72.0
81.2
73.1
71.6
76.2
75.3
72.4
71.3
82.6
75.6
74.8
72.8
75.7
71.7
72.9
NO DAMAGE
1 HOUR ( MIN )
TURN ON AFTER 2 HOUR
AFTER 12 HOURS
IN CHAMBER ON
CONTROL 50
NO DAMAGE
+ 0.03%(0~50)
I/P230 VAC
O/P99LOAD
Ta25
I/P480VAC/180VAC
O/P100 LOAD
Ta= -40
I/P483 VAC
O/PFULL LOAD
Ta= 50
HUMIDITY= 95 %R.H
I/P230 VAC
O/PFULL LOAD
TESTOK
TESTOK
TESTOK
+ 0.004 %(0~50)
VERDICT
P
P
P
P
P
Model: HLG-60H-C350
Test Report 6 / 7
Free Datasheet http://www.Datasheet4U.com

12 Page





SeitenGesamt 13 Seiten
PDF Download[ HLG-60H-C350 Schematic.PDF ]

Link teilen




Besondere Datenblatt

TeilenummerBeschreibungHersteller
HLG-60H-C35070W Single Output LED Power SupplyMean Well
Mean Well

TeilenummerBeschreibungHersteller
CD40175BC

Hex D-Type Flip-Flop / Quad D-Type Flip-Flop.

Fairchild Semiconductor
Fairchild Semiconductor
KTD1146

EPITAXIAL PLANAR NPN TRANSISTOR.

KEC
KEC


www.Datenblatt-PDF.com       |      2020       |      Kontakt     |      Suche